Tech Tip: Kia Constant Variable Valve Timing (CVVT) Oil Control Valve Inspection

Tech Tip: Kia Constant Variable Valve Timing (CVVT) Oil Control Valve Inspection

This bulletin provides information related to the Oil Control Valve (OCV) used in Constant Variable Valve Timing (CVVT) systems. If, at any time, the OCV is suspected as a cause of rough idling, poor acceleration, camshaft timing misalignment-related trouble codes, misfire-related trouble codes, etc., on a Kia vehicle equipped with a CVVT system, be sure to perform the OCV inspection procedure below before replacement.

This bulletin provides information related to the Oil Control Valve (OCV) used in Constant Variable Valve Timing (CVVT) systems. If, at any time, the OCV is suspected as a cause of rough idling, poor acceleration, camshaft timing misalignment-related trouble codes, misfire-related trouble codes, etc., on a Kia ­vehicle equipped with a CVVT system, be sure to perform the OCV inspection procedure below before ­replacement.

If the OCV operates normally, inspect for other ­engine malfunctions. Do not replace the OCV.

Note: Make sure the oil filter is OE; aftermarket oil filter flow rates differ and may affect the CVVT ­system’s performance. See Fig. 1. figure 1

Related Diagnostic Trouble Codes:

P0011 – “A” camshaft position – Timing over-­advanced or System performance (Bank 1)

P0012 – “A” camshaft position – Timing over-­retarded (Bank 1)

P0014 – “B” camshaft position – Timing over-­advanced or System performance (Bank 1)

P0015 – “B” camshaft position – Timing over-­retarded (Bank 1)

P0016 – Crankshaft position-Camshaft position ­correlation (Bank 1 Sensor A)

P0018 – Crankshaft position-Camshaft position ­correlation (Bank 2 Sensor A)

P0021 – “A” camshaft position – Timing over-­advanced or System performance (Bank 2)

P0022 – “A” camshaft position – Timing over-­retarded (Bank 2)

P0300 – Random/Multiple cylinder misfire detected

Basic Inspections:

– Monitor the waveforms of the crankshaft and camshaft position sensors with GDS.

– Check if the OCV connectors are securely connected and the pin tension is correct.

– Check that OCV connector seals are well seated; LH and RH OCVs are installed in place.

Note: The LH and RH OCV connectors are different in colors on V6 configurations.

– Measure resistance between the OCV power and ground terminals.

  > If resistance is within specifications, proceed to the OCV Test: Determine if OCV operates normally by providing 12V power and ground.

    – OCV is operating as designed; inspect other ­related areas.

  > If resistance is not within specifications, replace the affected OCV. (See chart below.)

OCV Supplier OCV Coil resistance (at 68° F)

Denso             6.9 ~ 7.9 Ω

Delphi             6.7 ~ 7.7 Ω

Siemens          6.8 ~ 8.0 Ω

– If the OCV does not move or cycle, examine for foreign objects like flashing or aluminum chips ­inside the OCV.

  > If no foreign objects are found, replace the OCV. 

  > If foreign objects are found in the OCV, remove the foreign material and then verify that the DTC or driveability concern is corrected.

1. Measure the resistance between the OCV power and ground terminals.

Measured Resistance (68° F)          Action to Take

Denso (6.9 ~ 7.9Ω)                  Check if the OCV

Delphi (6.7 ~ 7.7Ω)                  operates normally by

Siemens (6.8 ~ 8.0 Ω)             providing 12V power.

                                                (See Step 2.)

Infinity                                      Open circuit →

                                                Replace the OCV.

Abnormally low or                   Short circuit →

zero resistance                        Replace the OCV.

 

2. Check if the OCV operates normally by providing a 12V power supply. Do not apply voltage for longer than five seconds at a time; do not overheat the OCV windings. figure 2

Note: Careful attention is necessary to avoid a short circuit when providing the OCV with 12V power ­because the spacing between the OCV power and ground terminals is very narrow.

3. When 12V power is provided to the OCV, the OCV must move forward as shown in Fig 2.

A: Maximum retarded valve timing condition (12V not provided), Normally open. Figure 3

B: Maximum advanced valve timing condition (12V provided), Closed when energized.

4. If the OCV does not move forward, examine it carefully for a foreign object like an aluminum chip or flashing, which maybe jammed inside the OCV passage. See Fig. 3.

– Blow out the foreign object using compressed air, reuse the OCV and then verify that the fault is corrected.

The OCV can be replaced for the following conditions:

• Resistance is out of specification

• Valve does not move when voltage is applied

• Foreign debris cannot be removed from the OCV.

Courtesy of Kia Motors America.

 

 

You May Also Like

Maximize Your Scan Tool

Are you maximizing your scan tools to their full potential? Don’t let them be just an expensive code reader.

Scan Tool

If there’s a truth that extends across all computerized devices, it’s that we likely utilize only a fraction of the things they have the ability to do. Mobile phones are a great example. How many people do you know who only use them for calls, voicemail and text messages? We all know they do so much more.The scan tools we use every day fall into the same category. Are you maximizing yours to their full potential? Don’t let them be just an expensive code reader. That may be easier said than done, because it takes a lot of time to understand both the scan tool and how well it interacts with the vehicles you’re working on, but there are a few factors that can help you dive a little deeper into the functions at your fingertips.

Brake Lathe Basics

Resurfacing drums and rotors is a machining process with its own specific guidelines.

Refrigerant Oil Has to Be Right

Oil type is just as important as oil capacity.

Three bottles of refrigerant oil
Top 5 Tools: Steve Coffell, Auto World, Hazelwood, MO

Steve Coffell, a technician at Auto World in Hazelwood, MO, says his Top 5 Favorite Tools are: Related Articles – Lisle Low Profile Fuel Line Disconnect – Dent Fix Soft-Shock Mallet DF-SM76 Reduces Damage – New ProMAXX Diesel Fuel Injector Seal Puller/Saver ProKits   OTC Genisys Touch – Quick scan, bidirectional control Snap-on VANTAGE Pro

Wheel Bearing Adjustment Tools & Equipment

A wheel bearing that’s out of adjustment can reduce bearing life and can affect more than just the bearing. It’s important to adjust the wheel bearing endplay to the proper specifications. If the bearing set is adjusted too loose or too tight, it can cause the bearing to fail prematurely. There are a few types of assemblies, so using correct procedures and tools will ensure a comeback-free wheel bearing installation.

Other Posts

New Snap-on Limited Edition Speed Demon Roll Cab

Features include next-level organization, durability, security, mobility and exclusive Speed Demon emblem.

TEXA Releases IDC5 CAR 76.5.0 Update

IDC5 CAR 76.5.0 is characterized by over 2600 new possible selections for the major makes on the market worldwide.

Upgrade Your Air System: It’s Easier Than You Think

Improving your shop airflow is only a benefit, unless you like to spend more time, work harder and make less money.

air flow tubes
2024 Is Your Year to Be the Technician You Always Wanted to Be

As we enter 2024, strategic career planning is essential for success in the automotive repair industry.

happy new year 2024