Tech Tip: Hyundai Automatic Transaxle Oil Leak Between Transaxle and Transfer Case
If a Santa Fe 4WD or Tucson 4WD vehicle has an oil leak between the transaxle and transfer case, follow the repair procedure detailed in this Tech Tip.
Centric Parts Launches New Clutch Program and Catalog
Centric Parts says it is taking its automotive aftermarket expertise in a new direction with the launch of a comprehensive clutch program and catalog. The Centric Parts Clutch Systems Program and 2011 Clutch Systems Catalog (1938-2011) exhibit Centric Parts’ long-standing dedication to durability, quality and performance in the automotive aftermarket, the company noted.
Tech Tip: Hyundai Fail Safe Mode/Erratic, Hard Shifting/DTCs Set
An improperly functioning pulse generator on a 1996-2000 Elantra, 1997-2001 Tiburon or 1996-2004 Accent may result in the following conditions (Note: These conditions may be intermittent and difficult to duplicate.) • Diagnostic Trouble Codes: – P0717 – No pulse generator-A signal; – P0722 – No pulse generator-B signal; – P1624 – MIL-on request from TCM;
ATP Introduces New Automatic Transmission Catalog
ATP announces that 516 new part numbers were added with the release of the new Automatic Transmission Catalog catalog, No. AT-2011. More than 70 new transmission filter kits and more than 100 new master repair kits for domestic and import nameplates were added.
Tech Tip: DTC P0756 Diagnostic Tips on GM, Hummer and Saab Vehicles
Some technicians may have difficulty diagnosing DTC P0756, 2-3 Shift Valve Performance on 4L60-E, 4L65-E or 4L70E automatic transmissions. As detailed in the service manual, when the PCM detects a 4-3-3-4 shift pattern, DTC P0756 will set. Some customers may also describe a condition of a second, third or fourth gear start that may have the same causes but has not set this DTC yet.
Tech Feature: The Changing Face of Automatic Transmissions
Today’s computer systems have completely redefined automotive operation, particularly when it comes to transmission control.
Tech Tip: Volvo Rattle Noise From Dual Mass Flywheel
If a rattle noise is heard on a vehicle with a manual transmission, attention should be paid to the Dual Mass Flywheel (DMF). In the case of customer complaints, follow the steps listed in this Tech Tip.
Tech Tip: Lexus Fifth Gear Shudder
Models affected: 2004-’05 LX 470 vehicles produced before the Production Change Effective VIN: JTJHT00W#53553516 Some 2004 and 2005 model year LX 470 vehicles may exhibit a shudder (or vibration) sensation, usually accompanied by a cyclic droning noise, when lightly accelerating (less than 15% throttle) after the transmission shifts into 5th gear (usually between 35 and
Tech Feature: The DeLorean – Back From the Past
The DeLorean was often referred to as “the ethical sports car,” leading to the relatively small V6 engine and stainless-over-fiberglass construction with good fuel economy and long life in mind.
Tech Tip: Caddy’s DTC P0741 Set with Chuggle, Surge or Slip
Some customers may comment on the Service Engine Soon (SES) light being illuminated and a chuggle or surge being felt when driving at higher speeds. Technicians may observe on the Tech 2, an excessive torque converter clutch (TCC) slip speed and DTC P0741 set as Current or in History.
Replacing 4WD Transfer Case Actuator Motor and Range Selector Position Sensor for 2003-2007 GM Full-Size Trucks
ACDelco now offers the 4WD transfer case actuator motor and range selector position sensor for 2003-2007 GM full-size trucks. Both the actuator motor and sensor (part number 88962314) or the sensor only (part number 88962315) can be ordered. It is often more cost-effective to replace the sensor, but care must be used in the replacement procedure. On these vehicles, the transfer case actuator assembly consists of a permanent magnet DC motor and gear reduction assembly.
ATP-Inc. Announces Cash Rebate on ATP Solution Simple Synthetic Multi-Vehicle Automatic Transmission Fluid
Professional technicians who purchase No. AT-216 Synthetic Multi-Vehicle ATF before 12/01/2010 can receive a $10.00 rebate per quart (limit 6). That’s up to $60.00 total!